The loss of epithelial barrier integrity in bronchial and bronchiolar airways may be an initiating factor in the observed onset of toxicant-induced lung injuries. Acute 1-h inhalation exposures to aerosolized jet propulsion fuel 8 (JP-8) have been shown to induce cellular and morphological indications of pulmonary toxicity that was associated with increased respiratory permeability to 99mTc-DTPA. To address the hypothesis that JP-8 jet fuel-induced lung injury is initiated through a disruption in the airway epithelial barrier function, paracellular mannitol flux of BEAS-2B human bronchial epithelial cells was measured. Incubation of confluent cell cultures with non-cytotoxic concentrations of JP-8 or n-tetradecane (C14), a primary constituent of JP-8, for a 1-h exposure period resulted in dose-dependent increases of paracellular flux. Following exposures of 0.17, 0.33, 0.50, or 0.67 mg/ml, mannitol flux increased above vehicle controls by 10, 14, 29, and 52%, respectively, during a 2-h incubation period immediately after each JP-8 exposure. C14 caused greater mannitol flux increases of 37, 42, 63, and 78%, respectively, following identical exposure conditions. The effect on transepithelial mannitol flux reached a maximum at 12 h and spontaneously reversed to control values over a 48-h recovery period, for both JP-8 and C14 exposure. These data indicate that non-cytotoxic exposures to JP-8 or C14 exert a noxious effect on bronchial epithelial barrier function that may preclude pathological lung injury.