Investigation of adhesion of modern wound dressings: a comparative analysis of 56 different wound dressings

J Eur Acad Dermatol Venereol. 2011 Aug;25(8):933-9. doi: 10.1111/j.1468-3083.2010.03886.x. Epub 2010 Nov 10.


Introduction: In the process of chronic wound care, adhesive wound dressings may cause pain and injury in the wound environment during dressing changes. At present, no standardized test procedures are available for the investigation of adhesion of wound dressings. Therefore, our study aimed to test the adhesion of different wound dressings on steel as well as on healthy skin.

Methods: Within an open, comparative study, the adhesive areas of 56 wound dressings were investigated. The adhesives were categorized into acrylate (n = 23), silicone (n = 9), hydrocolloid (n = 17) and polyurethane groups (n = 7). Using an especially modified testing machine, the adhesion of the wound dressings was measured on steel as well as on the skin of healthy study participants, in compliance with the European EN 1939:2003 standard.

Results: The energy required to remove the wound dressings from human skin, was measured in Newton (N) and the following median values were obtained: hydrocolloid (2.25 N) > acrylate (1.14 N) > polyurethane (0.9 N) > silicone (0.7 N). The subjective pain intensity during the removal of the wound dressings was recorded using the visual analogue scale (VAS) with values ranging from 0 to 10. For hydrocolloid, it was 6.8, for acrylate 4.9, for polyurethane 3.1 and for silicone 2.5 points VAS. In comparison with human skin, the adhesion of wound dressings was significantly higher on steel (P < 0.0001), but was different for the different groups of wound dressings. Moreover, there was a statistically significant correlation between the adhesion and pain intensity (correlation coefficient 0.806; P = 0.01).

Conclusion: The knowledge about the widely differing adhesion properties of different wound dressings on the skin of patients should nowadays be considered during the individual selection of the applied products. Based on these data, different types of wound dressings could be developed, guaranteeing a good adhesion and a low traumatic risk when removed.

Publication types

  • Comparative Study

MeSH terms

  • Acrylates / adverse effects
  • Adhesives / adverse effects*
  • Bandages / adverse effects*
  • Colloids / adverse effects
  • Female
  • Humans
  • Male
  • Pain / etiology*
  • Polyurethanes / adverse effects
  • Silicones / adverse effects
  • Skin / injuries*
  • Statistics, Nonparametric
  • Steel


  • Acrylates
  • Adhesives
  • Colloids
  • Polyurethanes
  • Silicones
  • Steel