Simultaneous photocatalytic and microbial degradation of dye-containing wastewater by a novel g-C3N4-P25/photosynthetic bacteria composite

PLoS One. 2017 Mar 8;12(3):e0172747. doi: 10.1371/journal.pone.0172747. eCollection 2017.

Abstract

Azo dyes are very resistant to light-induced fading and biodegradation. Existing advanced oxidative pre-treatment methods based on the generation of non-selective radicals cannot efficiently remove these dyes from wastewater streams, and post-treatment oxidative dye removal is problematic because it may leave many byproducts with unknown toxicity profiles in the outgoing water, or cause expensive complete mineralization. These problems could potentially be overcome by combining photocatalysis and biodegradation. A novel visible-light-responsive hybrid dye removal agent featuring both photocatalysts (g-C3N4-P25) and photosynthetic bacteria encapsulated in calcium alginate beads was prepared by self-assembly. This system achieved a removal efficiency of 94% for the dye reactive brilliant red X-3b and also reduced the COD of synthetic wastewater samples by 84.7%, successfully decolorized synthetic dye-contaminated wastewater and reduced its COD, demonstrating the advantages of combining photocatalysis and biocatalysis for wastewater purification. The composite apparently degrades X-3b by initially converting the dye into aniline and phenol derivatives whose aryl moieties are then attacked by free radicals to form alkyl derivatives, preventing the accumulation of aromatic hydrocarbons that might suppress microbial activity. These alkyl intermediates are finally degraded by the photosynthetic bacteria.

MeSH terms

  • Bacterial Physiological Phenomena*
  • Biodegradation, Environmental*
  • Catalysis
  • Coloring Agents / metabolism*
  • Gas Chromatography-Mass Spectrometry
  • Photosynthesis*
  • Wastewater / microbiology*

Substances

  • Coloring Agents
  • Waste Water

Grants and funding

This work was financially supported by the State Key Laboratory of Photocatalysis on Energy and Environment (2014C05), the Fujian Provincial Department of Science and Technology (CN) (2015R1004-3) and by Environmental Protection Department of Fujian Province (2015R024). The funders had no role in study design, data collection and analysis, decision to publish, or preparation of the manuscript.