Prevalence, Persistence, and Diversity of Listeria monocytogenes and Listeria Species in Produce Packinghouses in Three U.S. States

Erika M Estrada; Alexis M Hamilton; Genevieve B Sullivan; Martin Wiedmann; Faith J Critzer; Laura K Strawn

doi:10.4315/0362-028X.JFP-19-411

Prevalence, Persistence, and Diversity of Listeria monocytogenes and Listeria Species in Produce Packinghouses in Three U.S. States

J Food Prot. 2020 Feb 1;83(2):277-286. doi: 10.4315/0362-028X.JFP-19-411.

Authors

Erika M Estrada¹, Alexis M Hamilton², Genevieve B Sullivan³, Martin Wiedmann³, Faith J Critzer², Laura K Strawn¹

Affiliations

¹ Department of Food Science and Technology, Eastern Shore Agricultural Research and Extension Center, Virginia Tech, Painter, Virginia 23420.
² Department of Food Science, University of Tennessee, Knoxville, Tennessee 37996.
³ Department of Food Science, Cornell University, Ithaca, New York 14853, USA.

PMID: 31961227
DOI: 10.4315/0362-028X.JFP-19-411

Abstract

Abstract: Listeria monocytogenes has emerged as a food safety concern for several produce commodities. Although L. monocytogenes contamination can occur throughout the supply chain, contamination from the packinghouse environment represents a particular challenge and has been linked to outbreaks and recalls. This study aimed to investigate the prevalence, persistence, and diversity of L. monocytogenes and other species of Listeria in produce packinghouses. A longitudinal study was performed in 11 packinghouses (whose commodities included microgreen, peach, apple, tomato, broccoli, cauliflower, and cucumber) in three U.S. states. In each packinghouse, 34 to 47 sites representing zones 2 to 4 were selected and swabbed. Packinghouses were visited four times over the packing season, and samples were tested for Listeria by following the U.S. Food and Drug Administration's Bacteriological Analytical Manual methods. Presumptive Listeria-positive isolates were confirmed by PCR. Species and allelic type (AT) were identified by sigB sequencing for up to eight isolates per sample. Among 1,588 samples tested, 50 (3.2%), 42 (2.7%), and 10 (0.6%) samples were positive for L. monocytogenes only, Listeria spp. (excluding L. monocytogenes) only, and both L. monocytogenes and Listeria spp., respectively. Five species of Listeria (L. monocytogenes, L. innocua, L. seeligeri, L. welshimeri, and L. marthii) were identified, and L. monocytogenes was the most prevalent species. The 102 Listeria-positive samples yielded 128 representative isolates (i.e., defined as isolates from a given sample with a different AT). Approximately 21% (21 of 102) of the Listeria-positive samples contained two or more ATs. A high AT diversity (0.95 Simpson's diversity index) was observed among Listeria isolates. There were three cases of L. monocytogenes or Listeria spp. repeated isolation (site testing positive at least twice) based on AT data. Data from this study also support the importance of drain and moisture management, because Listeria were most prevalent in samples collected from drain, cold storage, and wet nonfood contact surface sites.

Keywords: Listeria; Environmental monitoring; Nonfood contact surface; Subtyping.